18 May 2016 / Osram /

Intelligent light for VW parking garage saves 65% in energy

LED luminaires and intelligent light control from Osram installed in the VW employee parking garage at Baunatal have a payback duration of three years.

One of the largest and most modern logistics centres in Europe is located at Baunatal near Kassel in Germany – the original parts centre for Volkswagen. More than 450,000 VW original components are dispatched from the location to seven domestic sales centres and 83 countries. As part of the "Think Blue. Factory." campaign, Volkswagen also aimed to set standards in terms of energy saving, and as a consequence it was decided to sustainably upgrade the company’s employee car park with 500 parking lots. Energy savings of 65% are now achieved with the new lighting installation from Osram based on innovative LED luminaires and intelligent light control. Thanks to electricity cost savings, the investment is also paid back within three years.

Intelligent light for VW parking garage saves 65 in energy

With the "Think Blue. Factory." campaign, Volkswagen set itself the global target of cutting energy by 25% via refurbishment measures and new constructions. For upgrading the lighting system in the employee parking garage at Baunatal, VW was on the lookout for a complete solution that not only met requirements concerning energy economy but also provided significant added value in terms of safety, reliability and simple handling. Osram Lighting Solutions drew up a modern lighting concept for the purpose that cuts both energy consumption and costs and simultaneously improves convenience.

A new analysis process as the basis for the concept

The obsolete system was equipped with 350 1x58 W damp-proof luminaires with low-loss ballasts and a yearly consumption of approximately 140,000 kWh, corresponding to greenhouse gas emissions of 93 tons. As a first step, technicians from VW and Osram/Siteco carried out a detailed analysis together concerning future needs. Frequentation in the existing car park was measured by a data logger, and the measuring results were then input into the cost-efficiency calculation, which included return on investment. The new type of analysis supplies the basis for the concept of the new lighting system.

LED luminaires with state-of-the-art sensor and control technology

Based on these calculations, Osram Lighting Solutions then developed a comprehensive lighting solution for the VW parking garage. The car park is now equipped with Siteco Monsun 2 LED damp-proof luminaires. The housing material consists of glass fibre-reinforced polyester with IP66 protection rating, making the LED luminaires ideal for tough, durable use in parking garages. The wide light distribution characteristic optimally illuminates the complete car park.

Intelligent light for VW parking garage saves 65 in energy

The luminaires were combined with state-of-the-art sensor and control technology. Osram offers the PC 1 infrared sensor specifically for car park applications, featuring a detection characteristic matched for car park applications to precisely detect the motion of people and vehicles. "It achieves a very high tangential detection range of 40 metres in diameter, meaning less sensors are needed for such relatively large areas, and these areas are also reliably detected," explained Christian Remmelberger-König, Application Engineer at Osram Lighting Solutions. The sensor is ideal for rugged car park operation with IP54 protection. The intelligent Basic Industry control precisely matches the illuminance level to momentary lighting needs in the parking areas, and luminaires are controlled according to the specific parking level via DALI depending on levels of daylight and motion. 

Greater efficiency and safety

These plug & play solutions mean that electrical connection and commissioning of the control is very simple and time-saving for technicians. The control system is supported with a twilight switch in accordance with levels of daylight. If nobody is present in the sensor detection range the system runs in reduced mode that in this case is set to 20% of regular illuminance. If motion is detected in the detection range, the corresponding luminaires are immediately raised to 100% illuminance. In addition, the higher detection quality of the sensor means the delay time is reduced to a minimum - 10 minutes in the application. Both operating modes ensure 100% illuminance uniformity to strengthen the feeling of safety in the building. This achieves an optimal combination of energy-saving and safety atmosphere.

Energy savings of 65% with the new lighting system

The new lighting solution scores points both ecologically and economically, and helps VW to achieve its "Think Blue. Factory." targets. Energy reduction with the new system is a verifiable 65% and the return on investment (ROI) is three years. The 350 new luminaires together with high-resolution sensors and professional control technology annually save approximately 90,000 kWh and therefore 60 tons of CO2 emissions. As a full solution provider, Osram Lighting Solutions offers complete lighting solutions from a single source, and ensures problem-free projects from planning and implementation to installation.

top
Leave your comment
posted by Everbright Lighting new lighting feeling [2016.09.19 - 11:43]
ShenZhen Everbright Lighting Co.,LTD specialized in produce and design the indoor LED lights , Provide kinds of efficiency lighting device to help customer save the cost, www.li...com it's our website, welcome to visit and inquiry!
posted by Coreshine Led Linear lighting [2016.06.06 - 05:14]
Good design. Coreshine LED linear lighting system have good news for the car park lightings, we have sensor to effective the comming object . If your interesting, welcome to inquiry! sales21@cor...com
Lighting Directory
Videos
Activity Based Lighting in Offices
Flexible OLED light panel

Upcoming Events

Nov
30
Amsterdam Light Festival
The sixth edition of Amsterdam Light Festival takes place from 30 November 2017 until 21 January 2018. This year’s festival brings a fair share of surprises. Over 40 artworks and installations of artists, designers and architects from home and abroad will light up the city center of Amsterdam.
Jan
05
Iran Lighting Design Conference
ILDC stands for Iran Lighting Design conference where a big group of people from lighting industry (lighting designers, architects, industries, clients, and anybody interested in light) will gather together to discuss about the light and lighting design - There will be a lighting exhibition in the conference area where companies can show their products to their customers
Jan
06
Light Festival Lux Helsinki
The Lux In light art exhibition will be held for the second time at Cable Factory and present a wide spectrum of installations, from minimalistic works to video art. The exhibition will include both new installations and previously exhibited works by established artists, as well as by students from the Lighting Design and Sound Design Programme of the University of the Arts Helsinki.
Jan
17
Lighting Japan - LED / OLED Light-Tech Expo
Launched in 1972, NEPCON JAPAN has grown together with the Japanese & Asian electronics industry. Consisting of 7 shows specialised in essential areas for electronics manufacturing and R&D, the show has increased its value as an exhibition representing Asia's leading one-stop venue for all those involved in electronics industry. Furthermore, adding exhibitions for promising applications such as Automobiles, Wearable devices, Robots, and Smart factories, NEPCON JAPAN

New manufacturers